How to service and repair the front brake caliper on Lincoln Town Car?

The front brake caliper repair process should use DOT 3 brake fluid which preserves the caliper function while alternative types of fluid may result in permanent damage and failures. Before hoisting or jacking or towing a vehicle with air suspension you must disable the air suspension switch that is in the luggage compartment to stop unexpected air spring inflation or deflation. Position the vehicle with neutral gear selection onto a hoist system. Due to operation disconnect the brake caliper flow bolt while discarding both copper washers. After removing the two brake caliper guide pin bolts you should disconnect the brake caliper together with its brake pads. Inspections should be performed on the brake caliper and guide pins to check for damage or leaking conditions. Fresh brake caliper installation occurs when problems are detected. Install the guide pin boots correctly to prevent any damage during installation. First tighten the lower brake caliper guide pin bolt to attach the brake caliper to the anchor plate with two guide pin bolts secured to 36 Nm torque (27 ft. lbs.). Two new copper washers should be placed around the brake hose followed by installation of the brake caliper flow bolt and torque it to 48 Nm (35 ft. lbs.). The brake system needs bleeding followed by air suspension system activation if present and the brake master cylinder reservoir requires clean specified brake fluid to fill until the filler cap installation. Test the brake pedal operation several times before starting to drive the vehicle.

How to properly bleed a brake caliper using DOT 3 brake fluid on Lincoln Town Car?

Brake caliper bleeding requires DOT 3 brake fluid only because improper fluid selection will result in damage which makes the brakes unusable permanently. Follow proper precaution when working with brake fluid because skin contact will damage your eyes and cause fluid damage requires immediate handwashing. Workers should immediately rinse their eyes properly with water for 15 minutes after which they should find medical assistance if the irritation continues. You should drink water followed by vomiting induction until medical assistance arrives if you consume brake fluid. Wash away brake fluid spills from painted and plastic materials by using water. The master cylinder must receive the approved brake fluid during bleeding since running the fluid dry at any point is forbidden and fluids drained from the hydraulic system must never be used. The brake system demands no full bleed when the disc brake caliper was the only detached part. A box end wrench should be placed on the disc brake caliper bleeder screw before attaching a rubber drain tube to it and placing the free end of the tube in clean brake fluid. Assist the pedal pressure with an assistant who keeps applying force to the brake pedal. The bleeder screw should be loosened while the assistant keeps applying pressure on the brake pedal. Brake fluid should begin to drain before retightening the screw with pedal pressure maintained. And each time we obtain clear, bubble-free fluid should lead to a necessary refill of the master cylinder reservoir. Tighten the disc brake caliper bleeder screw as the last step.

OEM Lincoln Town Car Brake Caliper

Caliper

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

17 Brake Calipers found

View related parts
Lincoln Town Car Caliper Part Number: F5AZ2552A
$11.01 MSRP: $15.24
You Save: $4.23 (28%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Housing; Brake Caliper Repair Kit; Brake Caliper
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1991-1995 Lincoln Town Car | Base, Cartier, Cypress, Executive, Jack Nicklaus, Signature, Touring Edition, Tournament Edition | 8 Cyl 4.6 L GAS
View related parts
Lincoln Town Car Caliper Assembly, Passenger Side Part Number: G2MZ-2V552-BRM
$54.64 MSRP: $88.18
You Save: $33.54 (39%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Remanufactured Caliper Assembly - Brake Less Pads; Brake Caliper Repair Kit; Brake Caliper; Caliper; Caliper Assembly - Brake - Less Pads
- Position: Passenger Side
- Replaces: BRC-190-RM, 6L3Z-2V552-ACRM
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2004-2011 Lincoln Town Car | Designer Series, Executive, Executive L, Protection Series, Signature, Signature L, Signature Limited, Ultimate, Ultimate L | 8 Cyl 4.6 L FLEX, 8 Cyl 4.6 L GAS
View related parts
Lincoln Town Car Caliper, Passenger Side Part Number: F5AZ2B120A
$84.95 MSRP: $114.17
You Save: $29.22 (26%)
ADD TO CART
Product Specifications
- Other Name: Caliper Assembly - Brake; Brake Caliper Repair Kit; Brake Caliper; Caliper Assembly - Brake - Less Pads
- Position: Passenger Side
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1995-1997 Lincoln Town Car | Anniversary, Base, Cartier, Cypress, Executive, Signature, Touring Edition | 8 Cyl 4.6 L GAS
View related parts
Lincoln Town Car Caliper Assembly, Rear Driver Side Part Number: GU2Z-2V553-GRM
Product Specifications
- Other Name: Remanufactured Caliper Assembly - Brake Less Pads; Rear Left Disc Brake Caliper; Repair Kit.; Caliper
- Position: Rear Driver Side
- Replaces: BRCL-60-RM, BRCF-42, BRC-60-RM, F75Z-2553-BA, F75Z-2553-AE, F75Z-2V553-BARM, F75Z-2V563-BARM
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2004-2011 Lincoln Town Car | Designer Series, Executive, Executive L, Protection Series, Signature, Signature L, Signature Limited, Ultimate, Ultimate L | 8 Cyl 4.6 L FLEX, 8 Cyl 4.6 L GAS
View related parts
Lincoln Town Car Caliper, Driver Side Part Number: F8VZ-2B121-AB
Product Specifications
- Other Name: Caliper Assembly - Brake; Brake Caliper Repair Kit; Brake Caliper
- Position: Driver Side
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1998-2000 Lincoln Town Car | Cartier, Executive, Signature | 8 Cyl 4.6 L GAS
View related parts
Lincoln Town Car Caliper, Passenger Side Part Number: F8VZ-2B120-AB
Product Specifications
- Other Name: Caliper Assembly - Brake; Brake Caliper Repair Kit; Brake Caliper
- Position: Passenger Side
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1998-2000 Lincoln Town Car | Cartier, Executive, Signature | 8 Cyl 4.6 L GAS
View related parts
Lincoln Town Car Caliper, Rear Part Number: F7AZ-2552-AA
Product Specifications
- Other Name: Housing; Brake Caliper Repair Kit; Brake Caliper
- Position: Rear
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1996-1997 Lincoln Town Car | Anniversary, Base, Cartier, Executive, Signature, Touring Edition | 8 Cyl 4.6 L GAS
View related parts
Lincoln Town Car Caliper, Driver Side Part Number: F3VY-2V121-ARM
Product Specifications
- Other Name: Caliper Assembly - Brake; Brake Caliper Repair Kit; Brake Caliper; Caliper Assembly - Brake - Less Pads
- Position: Driver Side
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1993-1994 Lincoln Town Car | Base, Cartier, Cypress, Executive, Jack Nicklaus, Signature, Touring Edition, Tournament Edition | 8 Cyl 4.6 L GAS
View related parts
Lincoln Town Car Caliper, Passenger Side Part Number: F3VY-2V120-ARM
Product Specifications
- Other Name: Caliper Assembly - Brake; Brake Caliper Repair Kit; Brake Caliper; Caliper Assembly - Brake - Less Pads
- Position: Passenger Side
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1993-1994 Lincoln Town Car | Base, Cartier, Cypress, Executive, Jack Nicklaus, Signature, Touring Edition, Tournament Edition | 8 Cyl 4.6 L GAS
View related parts
Lincoln Town Car Caliper, Driver Side Part Number: F1VY-2V121-ARM
Product Specifications
- Other Name: Caliper Assembly - Brake; Brake Caliper Repair Kit; Brake Caliper; Caliper Assembly - Brake - Less Pads
- Position: Driver Side
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1984-1992 Lincoln Town Car | Base, Cartier, Cypress, Executive, Signature, Signature SE, Touring Edition | 8 Cyl 4.6 L GAS, 8 Cyl 5.0 L GAS
View related parts
Lincoln Town Car Caliper, Passenger Side Part Number: F1VY-2V120-ARM
Product Specifications
- Other Name: Caliper Assembly - Brake; Brake Caliper Repair Kit; Brake Caliper; Caliper Assembly - Brake - Less Pads
- Position: Passenger Side
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1984-1992 Lincoln Town Car | Base, Cartier, Cypress, Executive, Signature, Signature SE, Touring Edition | 8 Cyl 4.6 L GAS, 8 Cyl 5.0 L GAS
View related parts
Lincoln Town Car Caliper, Front Driver Side Part Number: 7W7Z-2B121-A
Product Specifications
- Other Name: Caliper Assembly - Brake; Disc Brake Caliper, Front Left; Brake Caliper Repair Kit; Caliper Assembly - Brake - Less Pads; Brake Caliper
- Manufacturer Note: Warranty Eligible
- Position: Front Driver Side
- Replaces: 6W7Z-2B121-AA, 3W1Z-2B121-AB, 3W7Z-2B121-AA, 6W1Z-2B121-AA
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2003-2011 Lincoln Town Car | Cartier, Cartier L, Designer Series, Executive, Executive L, Executive Protection Series, Protection Series, Signature, Signature L, Signature Limited, Ultimate, Ultimate L | 8 Cyl 4.6 L FLEX, 8 Cyl 4.6 L GAS
View related parts
Lincoln Town Car Caliper, Front Passenger Side Part Number: 7W7Z-2B120-A
Product Specifications
- Other Name: Caliper Assembly - Brake; Disc Brake Caliper, Front Right; Brake Caliper Repair Kit; Caliper Assembly - Brake - Less Pads; Brake Caliper
- Manufacturer Note: Warranty Eligible
- Position: Front Passenger Side
- Replaces: 3W1Z-2B120-AB, 6W7Z-2B120-AA, 3W7Z-2B120-AA, 6W1Z-2B120-AA
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2003-2011 Lincoln Town Car | Cartier, Cartier L, Designer Series, Executive, Executive L, Executive Protection Series, Protection Series, Signature, Signature L, Signature Limited, Ultimate, Ultimate L | 8 Cyl 4.6 L FLEX, 8 Cyl 4.6 L GAS
View related parts
Lincoln Town Car Caliper, Rear Driver Side Part Number: 7W1Z-2553-B
Product Specifications
- Other Name: Caliper Assembly - Brake; Disc Brake Caliper, Rear Left; Brake Caliper Repair Kit; Caliper Assembly - Brake - Less Pads; Brake Caliper
- Manufacturer Note: Warranty Eligible
- Position: Rear Driver Side
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2004-2011 Lincoln Town Car | Designer Series, Executive, Executive L, Protection Series, Signature, Signature L, Signature Limited, Ultimate, Ultimate L | 8 Cyl 4.6 L FLEX, 8 Cyl 4.6 L GAS
View related parts
Lincoln Town Car Caliper, Rear Passenger Side Part Number: 7W1Z-2552-B
Product Specifications
- Other Name: Caliper Assembly - Brake; Disc Brake Caliper, Rear Right; Brake Caliper Repair Kit; Caliper Assembly - Brake - Less Pads; Brake Caliper
- Manufacturer Note: Warranty Eligible
- Position: Rear Passenger Side
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2003-2011 Lincoln Town Car | Cartier, Cartier L, Designer Series, Executive, Executive L, Executive Protection Series, Protection Series, Signature, Signature L, Signature Limited, Ultimate, Ultimate L | 8 Cyl 4.6 L FLEX, 8 Cyl 4.6 L GAS
View related parts
Lincoln Town Car Caliper, Passenger Side Part Number: 1W1Z-2B120-AA
Product Specifications
- Other Name: Caliper With Pads; Brake Caliper Repair Kit; Brake Caliper
- Manufacturer Note: RH - with pads
- Position: Passenger Side
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2001-2002 Lincoln Town Car | Cartier, Cartier L, Executive, Executive L, Signature | 8 Cyl 4.6 L GAS
View related parts
Lincoln Town Car Caliper Part Number: YW1Z-2552-BA
Product Specifications
- Other Name: Caliper Assembly - Brake; Brake Caliper Repair Kit; Brake Caliper; Caliper Assembly - Brake - Less Pads
- Manufacturer Note: RH & LH Housing less pads
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1998-2000 Lincoln Town Car | Cartier, Executive, Signature | 8 Cyl 4.6 L GAS

Lincoln Town Car Brake Caliper

OEM Brake Caliper boasts unmatched quality. Each part goes through full quality checks. They adhere to Lincoln's official factory standards. These steps remove flaws and inconsistencies. So you can get Brake Caliper with long life and a perfect fit. Come to our website and find genuine Lincoln Town Car parts. We keep a wide inventory of OEM Town Car parts at the highly affordable prices. It's easy to search, compare, and pick what you need. You'll love the clear info and simple checkout. We offer top-rated customer service, and we reply fast. We also ship promptly to ensure your order arrives on time.

Being a very important component of braking system of Lincoln Town Car, Brake Caliper is responsible to change the hydraulic pressure delivered by master cylinder into mechanical force. This force act upon the brake pads to make them rub against the rotors to slow or stop the vehicle. There are fixed as well as floating calipers used in Lincoln Town Car models. While in the fixed type, the pistons are presented on both the sides of the rotor and applying even pressure, the floating type has the pistons only on one side and slide over the rotor surface which if not regulated, causes uneven wearing off. There have been different types of Brake Calipers used in the past years with variation being the physical design of building and the performance features of the calipers. The fixed calipers are usually more elaborate, yet outperform the floating calipers which, on the other hand, are less complex, but might have problems such as sticking and unequal wear. Other kinds of calipers are the performance oriented that improves stopping power and appearance and covers various driving styles and tastes.

Lincoln Town Car Brake Caliper Parts and Q&A

Caliper, Front Passenger Side
7W7Z-2B120-A
Q: How to service and repair the front brake caliper on Lincoln Town Car?
A:
The front brake caliper repair process should use DOT 3 brake fluid which preserves the caliper function while alternative types of fluid may result in permanent damage and failures. Before hoisting or jacking or towing a vehicle with Air Suspension you must disable the air suspension switch that is in the luggage compartment to stop unexpected air spring inflation or deflation. Position the vehicle with neutral gear selection onto a hoist system. Due to operation disconnect the brake caliper flow bolt while discarding both copper washers. After removing the two brake caliper guide pin bolts you should disconnect the brake caliper together with its Brake Pads. Inspections should be performed on the brake caliper and guide pins to check for damage or leaking conditions. Fresh brake caliper installation occurs when problems are detected. Install the guide pin boots correctly to prevent any damage during installation. First tighten the lower brake caliper guide pin bolt to attach the brake caliper to the anchor plate with two guide pin bolts secured to 36 Nm torque (27 ft. lbs.). Two new copper washers should be placed around the brake hose followed by installation of the brake caliper flow bolt and torque it to 48 Nm (35 ft. lbs.). The brake system needs bleeding followed by air suspension system activation if present and the brake master cylinder reservoir requires clean specified brake fluid to fill until the filler cap installation. Test the brake pedal operation several times before starting to drive the vehicle.
Caliper, Passenger Side
F8VZ-2B120-AB
Q: How to properly bleed a brake caliper using DOT 3 brake fluid on Lincoln Town Car?
A:
Brake caliper bleeding requires DOT 3 brake fluid only because improper fluid selection will result in damage which makes the brakes unusable permanently. Follow proper precaution when working with brake fluid because skin contact will damage your eyes and cause fluid damage requires immediate handwashing. Workers should immediately rinse their eyes properly with water for 15 minutes after which they should find medical assistance if the irritation continues. You should drink water followed by vomiting induction until medical assistance arrives if you consume brake fluid. Wash away brake fluid spills from painted and plastic materials by using water. The master cylinder must receive the approved brake fluid during bleeding since running the fluid dry at any point is forbidden and fluids drained from the hydraulic system must never be used. The brake system demands no full bleed when the disc brake caliper was the only detached part. A box end wrench should be placed on the disc brake caliper bleeder screw before attaching a rubber drain tube to it and placing the free end of the tube in clean brake fluid. Assist the pedal pressure with an assistant who keeps applying force to the Brake Pedal. The bleeder screw should be loosened while the assistant keeps applying pressure on the brake pedal. Brake fluid should begin to drain before retightening the screw with pedal pressure maintained. And each time we obtain clear, bubble-free fluid should lead to a necessary refill of the master cylinder reservoir. Tighten the disc brake caliper bleeder screw as the last step.